Table of Contents
Advertisement
Quick Links
SERVICE MANUAL
Ver 1.0 2004. 02
• The tuner and CD sections have no adjustments.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
FM1/FM2:
87.5 – 108 MHz
(at 50 kHz step)
FM3:
65 – 74 MHz
(at 30 kHz step)
Aerial terminal
External aerial connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
531 – 1,602 kHz
Aerial terminal
External aerial connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
AM: 30 µV
Sony Corporation
9-877-558-01
2004B04-1
e Vehicle Company
© 2004. 02
Published by Sony Engineering Corporation
CDX-R3300EE
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
SPECIFICATIONS
Power amplifier section
Outputs
Speaker impedance
Maximum power output 50 W × 4 (at 4 ohms)
General
Outputs
Inputs
Tone controls
FM/AM COMPACT DISC PLAYER
East European Model
NEW
MG-611MA-186//Q
KSS1000E
Speaker outputs
(sure seal connectors)
4 – 8 ohms
Audio outputs terminal
(rear/sub switchable)
Power aerial relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
Remote controller input terminal
Aerial input terminal
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
– Continued on next page –
1
Advertisement
Table of Contents
Related Manuals for Sony CDX-R3300EE
Summary of Contents for Sony CDX-R3300EE
- Page 1 30 – 15,000 Hz Tuning range 531 – 1,602 kHz Aerial terminal External aerial connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity AM: 30 µV FM/AM COMPACT DISC PLAYER Sony Corporation 9-877-558-01 2004B04-1 e Vehicle Company © 2004. 02 Published by Sony Engineering Corporation...
- Page 2 COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
- Page 3 CDX-R3300EE UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.) : LEAD FREE MARK Unleaded solder has the following characteristics.
-
Page 4: Table Of Contents
CDX-R3300EE TABLE OF CONTENTS 1. GENERAL Location of controls ..............5 Connections ................6 2. DISASSEMBLY 2-1. Sub Panel Assy ..............8 2-2. CD Mechanism Block ............9 2-3. Main Board ................. 9 2-4. Chassis (T) Sub Assy ............10 2-5. -
Page 5: General
CDX-R3300EE SECTION 1 GENERAL This section is extracted from instruction manual. -
Page 6: Connections
CDX-R3300EE Connections... - Page 7 CDX-R3300EE...
-
Page 8: Disassembly
CDX-R3300EE SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. 2-1. SUB PANEL ASSY (Page 8) 2-2. CD MECHANISM BLOCK (Page 9) 2-10. SERVO BOARD 2-3. MAIN BOARD 2-4. CHASSIS (T) SUB ASSY (Page 13) -
Page 9: Cd Mechanism Block
CDX-R3300EE 2-2. CD MECHANISM BLOCK 7 bracket (CD) 5 CD mechanism block 6 two screws (+PTT 2.6 x 4) 2 screw (+PTT 2.6 x 6) 1 screw (+PTT 2.6 x 6) 4 CN350 2-3. MAIN BOARD 1 three ground point screws (+PTT 2.6 x 6) -
Page 10: Chassis (T) Sub Assy
CDX-R3300EE 2-4. CHASSIS (T) SUB ASSY 4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2) 6 chassis (T) sub assy 5 SENSOR board 3 claw 2-5. ROLLER ARM ASSY 3 washer 5 roller arm assy... -
Page 11: Chassis (Op) Assy
CDX-R3300EE 2-6. CHASSIS (OP) ASSY qa chassis (OP) assy 0 coil spring (damper) lever (D) 4 washer 1 CN1 9 two coil springs (damper) 5 gear (LE1) slider (R) 3 tension coil spring (KF) 2 Remove the six solderings. 2-7. OPTICAL PICK-UP... -
Page 12: Sl Motor Assy (M902)
CDX-R3300EE 2-8. SL MOTOR ASSY (M902) 1 screw (+P 1.4 x 1.8) 2 SL motor assy (M902) 2-9. LE MOTOR ASSY (M903) 8 screw 0 woam (LEB) assy (+M 1.7 x 2.5) 9 bearing (LEB) 2 washer qa screw (+M 1.7 x 2.5) -
Page 13: Servo Board
CDX-R3300EE 2-10. SERVO BOARD 6 SERVO board 1 Remove the eight solderings. 2 Remove the three solderings. 4 toothed lock screw (M 1.7) 5 claw 3 CN1... -
Page 14: Diagrams
CDX-R3300EE SECTION 3 DIAGRAMS 3-1. IC PIN DESCRIPTIONS • IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2)) Pin No. Pin Name Pin Description MIRR Mirror signal input/output (Not used in this set) DFCT Defect signal input/output (Not used in this set) Focus OK signal input/output —... - Page 15 CDX-R3300EE Pin No. Pin Name Pin Description FILI Filter signal input Charge pump output AVDD5 — Analog power supply pin (+3.3 V) DDVROUT DC/DC converter output DDVRSEN DC/DC converter output voltage monitor signal input AVSS5 — Analog ground DDCR Reset signal input —...
- Page 16 CDX-R3300EE Pin No. Pin Name Pin Description SENS SENS signal output SCLK Clock signal input ATSK Input/output for anti-shock. (Fixed at L in this set) WFCK WFCK signal output (Not used in this set) XUGF XUGF signal output (Not used in this set)
- Page 17 Not used. (Open) DAVSS — D/A converter power supply (–) pin UNISO SONY-BUS data output (Not used in this set) UNISI SONY-BUS data input (Not used in this set) UNICKO SONY-BUS clock output (Not used in this set) Retractable CD door open/close detection switch input...
- Page 18 CDX-R3300EE Pin No. Pin Name Pin Description E2P_CKO Serial clock output to EEPROM communication. E2P_SIO Serial data input/output with EEPROM communication. DOORIND Not used. (Open) AMPSTB Standby control output to power amp IC. Not used. (Open) FLS.SO/LCDSO Serial data output to LCD driver IC.
- Page 31 CDX-R3300EE IC400 BD3808FS-FE2 FADER FADER FADER FADER (0~-58, (0~-58, (0~-58, (0~-58, C BUS -dB) -dB) -dB) -dB) GAIN+ATT LOGIC (+10~-29, -dB) EFFECT (0dB~ EFFECT (0dB~ 2ND ORDER LPF fc:OFF,80,120,160Hz +20dB,2dB STEP) +20dB,2dB STEP) 2ND ORDER Q: 0.707 BASS fo:60,70,80,100,120,140,160,200Hz TONE TONE Q:0.5,0.75,1,1.25...
-
Page 32: Exploded Views
CDX-R3300EE SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. -
Page 33: Front Panel Section
CDX-R3300EE 4-2. FRONT PANEL SECTION not supplied (KEY board) not supplied LCD901 not supplied not supplied not supplied not supplied supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-3384-683-2 PANEL SUB ASSY, FRONT... -
Page 34: Cd Mechanism Section (1)
CDX-R3300EE 4-3. CD MECHANISM SECTION (1) (MG-611MA-186//Q) not supplied (SENSOR board) not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-444-A CHASSIS (T) SUB ASSY 3-352-758-31 SCREW (M1.7), TOOTHED LOCK 3-253-729-11 SPRING (LTR), TENSION COIL... -
Page 35: Cd Mechanism Section (2)
CDX-R3300EE 4-4. CD MECHANISM SECTION (2) (MG-611MA-186//Q) (including M901) M902 not supplied not supplied not supplied not supplied The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. -
Page 36: Cd Mechanism Section (3)
CDX-R3300EE 4-5. CD MECHANISM SECTION (3) (MG-611MA-186//Q) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-348-993-01 WASHER 3-259-467-11 BRACKET (LEM) 3-259-024-01 WHEEL (RA), WORM 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-3372-441-A ARM ASSY, ROLLER A-3372-450-A WORM (LEB) ASSY... -
Page 37: Cd Mechanism Section (4)
CDX-R3300EE 4-6. CD MECHANISM SECTION (4) (MG-611MA-186//Q) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-259-429-11 WHEEL (LE), WORM 3-899-829-01 WASHER (SLIT) 3-344-223-01 WASHER 3-259-032-01 GEAR (LE2) 3-259-470-11 GEAR (LE1) A-3337-998-A CHASSIS (M) BLOCK ASSY 3-253-755-12 LEVER (D) -
Page 38: Electrical Parts List
CDX-R3300EE SECTION 5 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 39 CDX-R3300EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R925 1-216-807-11 METAL CHIP 1/10W S914 1-771-884-31 SWITCH, TACTILE (SCRL) R926 1-216-805-11 METAL CHIP 1/10W S915 1-771-884-31 SWITCH, TACTILE (SENS) R931 1-216-809-11 METAL CHIP 1/10W S916...
- Page 40 CDX-R3300EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C471 1-126-964-11 ELECT 10uF D311 8-719-200-82 DIODE 11ES2 C481 1-126-964-11 ELECT 10uF D312 8-719-200-82 DIODE 11ES2 C491 1-126-947-11 ELECT 47uF D351 8-719-041-79 DIODE MA721WA-TX C492 1-107-826-11 CERAMIC CHIP 0.1uF...
- Page 41 CDX-R3300EE MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark L354 1-500-245-11 INDUCTOR, FERRITE BEAD R441 1-216-809-11 METAL CHIP 1/10W L355 1-469-876-11 INDUCTOR, FERRITE BEAD R442 1-216-841-11 METAL CHIP 1/10W L356 1-500-245-11 INDUCTOR, FERRITE BEAD R443...
- Page 42 CDX-R3300EE MAIN SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < VIBRATOR > 1-104-609-11 ELECT CHIP 100uF 1-125-837-11 CERAMIC CHIP 6.3V X500 1-813-160-11 VIBRATOR, CERAMIC (27.648MHz) 1-125-837-11 CERAMIC CHIP 6.3V X501 1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz) 1-164-156-11 CERAMIC CHIP 0.1uF...
- Page 43 CDX-R3300EE SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-218-971-11 RES-CHIP 1/16W 1-218-941-81 RES-CHIP 1/16W 1-218-971-11 RES-CHIP 1/16W 1-218-990-11 SHORT CHIP 1-218-965-11 RES-CHIP 1/16W 1-218-941-81 RES-CHIP 1/16W 1-218-965-11 RES-CHIP 1/16W 1-218-941-81 RES-CHIP 1/16W 1-218-965-11 RES-CHIP...
- Page 44 CDX-R3300EE Ref. No. Part No. Description Remark MISCELLANEOUS *************** 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER) 0 153 8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP) A-3372-448-A CHASSIS (OP) SUB ASSY (including M901) F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A M902 A-3372-447-A MOTOR ASSY, SL (SLED)
- Page 45 www.s-manuals.com...