SRF-HM03V TABLE OF CONTENTS Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be dam- GENERAL ..............3 aged by heat. DISASSEMBLY 2-1. Disassembly Flow ............4 2-2.
SRF-HM03V SECTION 1 This section is extracted from instruction manual. GENERAL (Left) POWER ON/OFF Battery compartment lid (Right) Light reflector (L) This reflector TUNE +* /— reflects car lights TV/WB/FM SENS at night for your DX/LOCAL safety. VOL* Light reflector (R)
SRF-HM03V SECTION 2 DISASSEMBLY • This set can be disassembled in the order shown below. 2-1. DISASSEMBLY FLOW 2-2. POWER BOARD 2-4. MICON BOARD, (Page 4) MAIN BOARD (Page 5) 2-3. CABLE SETTING 2-5. PUTTING THE (Page 5) SHEET (A) (Page 6) Note: Follow the disassembly procedure in the numerical order given.
SRF-HM03V 2-3. CABLE SETTING Note: When installing the POWER board, set the cables as shown figure. slit slit slit slit slit POWER board 2-4. MICON BOARD, MAIN BOARD 5 claw 3 two screws (1.7) 6 cabinet assy front (R) qs MAIN board q;...
SRF-HM03V SECTION 3 ELECTRICAL ADJUSTMENTS 0 dB=1 µV AM VCO VOLTAGE ADJUSTMENT Adjustment Part Frequency Display Reading on Digital Voltmeter [AM] 1.30 ± 0.05 V 530 kHz Setting: 8.10 ± 1.00 V Confirmation 1710 kHz BAND: AM Put the lead-wire...
SRF-HM03V SECTION 4 DIAGRAMS 4-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAM Note on Printed Wiring Boards: Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF • X : parts extracted from the component side.
SRF-HM03V • 4-2. SCHEMATIC DIAGRAM • See page 12 for Waveforms. • See page 12 for IC Block Diagrams. See page 13 for IC Pin Function Description. R112 4.7k HEADPHONE Q6,7 (R-CH) 220k 1000p AM BAND R113 SWITCHING 100k 100k 100p 4.7k...
Page 13
SRF-HM03V • IC Pin Function Description MICON BOARD IC301 TC9329FA-112 (SYSTEM CONTROLLER) Pin No. Pin Name Description 1 to 4 COM1 to COM4 Common drive signal output to the liquid crystal display 5 to 15 S1 to S11 Segment drive signal output to the liquid crystal display...
SRF-HM03V SECTION 5 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they • Items marked “*” are not stocked since they may have some difference from the original are seldom required for routine service. Some one. delay should be anticipated when ordering •...
SRF-HM03V SECTION 6 ELECTRICAL PARTS LIST POWER MAIN NOTE: • Due to standardization, replacements in the • Items marked “*” are not stocked since they When indicating parts by reference number, please include the board. parts list may be different from the parts speci- are seldom required for routine service.
Page 18
SRF-HM03V MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C202 1-162-910-11 CERAMIC CHIP 0.25PF 50V < RESISTOR > C203 1-162-915-11 CERAMIC CHIP 10PF 0.5PF C204 1-164-156-11 CERAMIC CHIP 0.1uF 1-216-845-11 METAL CHIP 100K 1/10W 1-216-845-11 METAL CHIP...
Page 20
SRF-HM03V REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision...