Page 1
No. 0106 CP2025T C2125T/S CL2125T/S CP2125T/S C2142N/S SERVICE MANUAL CL2142AN/S CP2142AN/S MANUEL D’ENTRETIEN C2842N/S WARTUNGSHANDBUCH CL2842AN/S CP2842AN/S CAUTION: Data contained within this Before servicing this chassis, it is important that the service technician Service manual is subject to read the “Safety Precautions” and “Product Safety Notices” in this alteration for improvement.
Page 2
Contents Contents..............................2 Safety Precautions..........................3 TV Set switched off..........................3 Measurement............................3 PERI-TV SOCKET........................... .3 SCART 1..............................3 SCART 2..............................3 INTRODUCTION............................3 SMALL SIGNAL PART WITH TDA884X....................3-4 TUNER..............................5 VIDEO SWITCH TEA6415C........................5 AM DEMODULATOR TDA9830.......................6 DIGITAL TV SOUND PROCESSOR TDA9875..................6 SOUND OUTPUT STAGE TDA2615/TDA2616Q..................6 VERTICAL OUTPUT STAGE WITH TDA8351/TDA8356................7 VIDEO OUTPUT AMPLIFIER TDA6107Q....................
Page 3
DO NOT CHANGE ANY MODULE UNLESS THE SET IS SWITCHED OFF This...
Page 4
possible when the display section of the receiver is used as a monitor. The ident output is supplied to the tuning system via the I²C-bus. The video ident circuit can be made less sensitive by means of the STM bit. This mode can be used during search tuning to avoid that the tuning system will stop at very weak input signals.
Page 5
When the TV receiver is switched-on, the RGB output signals are blanked and the black current loop will try to set the right picture tube bias levels.Via the AST bit a choice can be made between automatic start-up or a start-up via the m-processor. 3.
Page 6
AM-demodulator compared to an internal reference voltage.The maximum charge/discharge current is approximately 5mA. 400KHz 700KHz...
Page 8
The memory is compatible with the I²C standard, two wire serial interface which uses a bi-directional data bus and serial clock. I²C I²C-bus control of various functions...
Page 20
I²C I²C 26. Serial data input/output : High level input voltage : Min : 3VDC, Max : Vcc : Low level input voltage : Min : -0.3VDC, Max : 1.5VDC : Low level output voltage : Max : 0.4VDC High level input voltage: Min : 3VDC, Max : Vcc ow level input voltage : Min : -0.3VDC, Max : 1.5VDC : Low level output voltage : Max : 0.4VDC...
Page 23
110° 110° Select OPTION using $ or ' button and press & or % button to enter it. To select different option bytes, use $ or ' button. Using & or % button select the bit you want to set and then set it pressing 0 or 1 button.
Page 27
Option 0. note1 note1 note 1: Xa,Xb Pal M, Pal N, Ntsc M Pin 34 : 3.58 (1, 2 or 3 crystals) Pin 35 : No crystal Pal BG, Pal DK, Pal I/I+, Secam BG, Secam DK, Secam L/L’, Secam K1 Pin 34 : No crystal Pin 35 : 4.43 (1 crystal) Pal BG, Pal DK, Pal I/I+, Secam BG, Secam DK, Secam L/L’, Secam K1, Pal M, Pal N, Ntsc M...
Page 31
note 5: IF M,N 45.75 MHz S&N American Models , Tuner UV1336 (Only Pal M/N, Ntsc M) IF M,N 38.9 MHz Euro M,N Models , Standard Tuner Note 6: Aps ( Only for PLL ) A.P.S. done A.P.S. set note 7: No headphone Headphone available note 8:...
Page 41
Option 27. LANGUAGE AVAILABLE 1 DANISH SWEDISH ITALIAN PORTUGUESE SPANISH FRENCH GERMAN ENGLISH 1: Language available 0: Language not available Option 28. LANGUAGE AVAILABLE 2 RUSSIA, BULGARIAN, RUMANIAN, CROATIC, POLISH CZECH HUNGARY TURKEY 1: Language available 0: Language not available Option 29.
Page 44
T1, T0: No TV Text Simple TV Text ( One page ) Fasttext/Toptext TV Text ( Eight pages) note 2 : Child Lock On (Active) note 3 : Standard available Standard not available Standard available note 4 : Equalizer available Equalizer not available Equalizer available note 5 :...
Page 59
Option 63. AUTO SWITCH THRESHOLD note 1 note 1 note 1 note 1 note 1 note 1 note 1 note 1 note 1 : Auto FM_AM : FP Register 21h Automatic switching with external threshold B2, B1, B0 : Bit10, Bit9,Bit8 of the register B7, B6, B5, B4,B3 : Bit7,Bit6, Bit5, Bit4, Bit3 of the register (Bit2,Bit1 of the register is always 0 and Bit0 of the register is always 1.) b7 b6 b5 b4 b3 b2 b1 b0...
Page 60
ADJUST 00-65 ADJUST 00 White Point RED ADJUST 01 White Point GREEN ADJUST 02 White Point BLUE ADJUST 03 ADJUST 04 IF-PLL Negative ADJUST 05 IF-PLL Positive ADJUST 06 Y-Delay PAL ADJUST 07 Y-Delay SECAM ADJUST 08 Y-Delay NTSC ADJUST 09 Y-Delay OTHER ADJUST 10 4:3 Vertical Zoom...
Page 61
ADJUST 51 Super Zoom EW Parabola Width ADJUST 52 Super Zoom EW Corner Parabola ADJUST 53 Super Zoom EW Trapezium ADJUST 54 Cinema Vertical Zoom ADJUST 55 Cinema Vertical Scroll ADJUST 56 Cinema Horizontal Shift ADJUST 57 Cinema Vertical Slope ADJUST 58 Cinema Vertical Amplitude ADJUST 59...
Page 62
Part No. Description VS30000332 CAP SMD 4.7NF 50V K (0805) VS30000332 CAP SMD 4.7NF 50V K (0805) C029 VS30000294 CAP SMD 100NF 50V K (0805) C030 VS30000294 CAP SMD 100NF 50V K (0805) C031 VS30000294 CAP SMD 100NF 50V K (0805) C032 VS30000294 CAP SMD 100NF 50V K (0805)
Page 63
Part No. Description C433 VS30000284 CAP SMD 1NF 50V K R (0805) C434 VS30000284 CAP SMD 1NF 50V K R (0805) C435 VS30000074 CAP MKT 100NF 63V J C436 VS30000074 CAP MKT 100NF 63V J C437 VS30000362 CAP EL 1UF 50V M C438 VS30000312 CAP SMD 22NF 50V K (0805)
Page 64
Part No. Description C612 VS30000356 CAP EL 100UF 63V M C617 VS30000156 CAP MKP 430NF 250V J C618 VS30000394 CAP EL 3.3UF 160V M C632 VS30000360 CAP EL 1000UF 25V M C660 VS30009208 CAP CER 470PF 1KV K (PULSE) C661 VS30009208 CAP CER 470PF 1KV K (PULSE) C700...
Page 65
F801 VS35000136 FUSE HOLDER TK79-A (GRAY) IC100 VS30001524 IC TDA2614 IC401 VS30001575 IC TDA8842/N2 IC501 VS30015255 IC SDA5555 HITACHI IC502 VS20063994 IC 24C08 WP 3.3V Program. UK (C2142N,C2842N/S) IC502 VS20058672 IC 24C08 WP 3.3V Program. UK (C2125S/T) IC502 VS20058678 IC 24C08 J19¥251100200A10...
Page 66
VS30001830 CONN MALE 2P TOP BLUE PL892 VS30007118 PIN F 2P/7.5MM PL893 VS30007118 PIN F 2P/7.5MM PL900 VS30015752 SOCKET CRT NARROWNECK W/GND HITACHI PL901 VS30001783 CONN.MALE 5P (2005) PL902 VS30015629 CONN.MALE 5P (2005) BLACK PL903 VS35000135 TEST PIN 1.1MM PL903...
Page 68
Part No. Description R202 VS30000459 RES CF 1/4W 100R J R203 VS30000471 RES CF 1/4W 10K J R204 VS30000459 RES CF 1/4W 100R J R205 VS30000459 RES CF 1/4W 100R J R212 VS30000727 RES SMD 1/10W 47K J (0805) R400 VS30000717 RES SMD 1/10W 470R J (0805) R401...
Page 69
Part No. Description R512 VS30000727 RES SMD 1/10W 47K J (0805) R513 VS30000727 RES SMD 1/10W 47K J (0805) R514 VS30000727 RES SMD 1/10W 47K J (0805) R515 VS30000727 RES SMD 1/10W 47K J (0805) R516 VS30000464 RES SMD 1/10W 100R J R517 VS30000464 RES SMD 1/10W 100R J...
Page 70
Part No. Description R585 VS30000480 RES SMD 1/10W 100K J (0805) R586 VS30000480 RES SMD 1/10W 100K J (0805) R587 VS30000712 RES CF 1/4W 470R J R589 VS30000529 RES SMD 1/10W 1.5K J R590 VS30000721 RES SMD 1/10W 4.7K J R592 VS30000475 RES SMD 1/10W 10K J 0805...
Page 71
Part No. Description R835 VS30000580 RES CF 1/4W 22R J R836 VS30000706 RES CF 1/4W 47R J R844 VS30000471 RES CF 1/4W 10K J R845 VS30001257 RES MG 1/2W 4.7M J R849 VS30000534 RES SMD 1/10W 15K J (0805) R850 VS30000569 RES CF 1/4W 180K J R858...
Page 72
Model Variant Assembly Parts C2125S/CL2125S/CP2125S BACK CVR.XX6-7-8-9/6-25/26 SILVER (P) VS20053756 BUTTON ASSY.XX66/86 (SILVER/P) VS20056985 BUTTON FUNCTION XX66/86 SILVER (P) VS20056986 BUTTON ON/OFF XX66/86 (SILVER) (P) VS20056988 FRONT 5586-AV W/H&J SILVER (P) VS20092618 C2142S/CL2142S/CP2142S BACK CVR.5X70/71-2172 SILVER (P) VS20039118 BUTTON ASSY 2172H (4T) (SILVER/P) VS20093733 BUTTON FUNCTION 2172H (SILVER/P) VS20093730...
Page 75
Hitachi, Ltd. Tokyo, Japan International Sales Division THE HITACHI ATAGO BUILDING, No. 15 –12 Nishi Shinbashi, 2 – Chome, Minato – Ku, Tokyo 105-8430, Japan. Tel: 03 35022111 HITACHI EUROPE LTD. HITACHI EUROPE S.A. Dukes Meadow 364, Kifissias Ave. & 1, Delfon Str.