Sony ICD-P520 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Voice Recorder
  5. ICD-P520 - Digital Voice Recorder
  6. Service manual
Sony ICD-P520 Service Manual

Sony ICD-P520 Service Manual

Hide thumbs Also See for ICD-P520:
Table of Contents

Advertisement

Quick Links

Download this manual
SERVICE MANUAL
Ver. 1.1 2007.06
IC recorder section
Recording media
recording
Actual usable capacity may be smaller.
Recording time
HQ: 29 hours 45 minutes
SP: 79 hours 20 minutes
LP: 130 hours 25 minutes
Freqency range
HQ: 260 Hz - 6,800 Hz
SP/LP: 220 Hz - 3,400 Hz
FM radio section (P530F)
Frequency range
87.5 - 108 MHz
IF 225 kHz
Antennas
Headphone cord antenna
General
Speaker
Approx. 2.8 cm (1 1/8 in.) dia.
Power output
250 mW
Sony Corporation
9-887-636-02
2007F04-1
Personal Audio Division
©
2007.06
Published by Sony Techno Create Corporation
ICD-P520/P530F
SPECIFICATIONS
Canadian Model
Input/Output
Headphone jack (minijack) for 8 - 300 ohms
ear receiver/headphones
Microphone jack (minijack, monaural)
Plug in power
Minimum input level 0.6 mV
3 kilohms or lower impedance microphone
USB connector
Power requirements
Two LR03 (size AAA) alkaline batteries: 3 V DC
Dimensions (w/h/d) (not incl.
projecting parts and controls)
34.6 × 109.5 × 18.0 mm (1 3/8 × 4 3/8 × 23/32
in.)
Mass (incl. batteries)
68 g (2.4 oz)
Supplied accessories
Operating instructions (1)
LR03 (size AAA) alkaline batteries (2)
Headphone (1) (P520: E, CH, KR/P530F)
Carrying pouch (1) (E, CH, KR model)
USB connecting cable (1)
Application software (CD-ROM) (1)
change without notice.
• Abbreviation
CH : Chinese model
KR : Korea model
US Model
ICD-P520/P530F
ICD-P520
AEP Model
UK Model
E Model
ICD-P520/P530F
Chinese Model
ICD-P520
IC RECORDER

Advertisement

Table of Contents
loading

Related Manuals for Sony ICD-P520

Summary of Contents for Sony ICD-P520

  • Page 1 Approx. 2.8 cm (1 1/8 in.) dia. Application software (CD-ROM) (1) Power output 250 mW change without notice. • Abbreviation CH : Chinese model KR : Korea model IC RECORDER Sony Corporation 9-887-636-02 2007F04-1 Personal Audio Division © 2007.06 Published by Sony Techno Create Corporation...

  • Page 2: Table Of Contents

    4-5. Printed Wiring Board the lead free mark due to their particular size) – USB/FM Section (ICD-P530F) – ........ 14 4-6. Printed Wiring Board – USB Section (ICD-P520) – ..15 : LEAD FREE MARK 4-7. Schematic Diagram Unleaded solder has the following characteristics.

  • Page 3: General

    ICD-P520/P530F SECTION 1 This section is extracted from instruction manual. GENERAL Index to Parts and Controls Index to Parts and Controls Main unit (ICD-P520) Main unit (ICD-P530F) MIC (built-in microphone) (headphone) jack MIC (built-in microphone) (headphone) jack (microphone) jack (microphone) jack...

  • Page 4: Disassembly

    ICD-P520/P530F SECTION 2 DISASSEMBLY • This set can be disassembled in the order shown below. 2-1. CASE (FRONT) ASSY (Page 4) 2-2. MAIN BOARD (Page 5) 2-3. USB BOARD (P520), USB/FM BOARD (P530F) (Page 5) Note: Follow the disassembly procedure in the numerical order shown below.

  • Page 5: Main Board

    ICD-P520/P530F 2-2. MAIN BOARD screw insulating sheet MAIN board CN2001 S701 2-3. USB BOARD (P520), USB/FM BOARD (P530F) two screws USB board (P520), USB/FM board (P530F)

  • Page 6: Test Mode

    ICD-P520/P530F SECTION 3 TEST MODE 1. Outline of the TEST MODE 5-3. BEEP Test The TEST MODE is designed to help verify the set when servic- To enter the BEEP Test, press the [ERASE] (P520), [FM•i/ ing it. (P530F) button.

  • Page 7: Hold-On

    ICD-P520/P530F • SUSPEND Test With the VBUS ON, turn the [HOLD] switch ON to enter the SUS- HOLD PEND mode. When this mode is cancelled, the VBUS is turned OFF. with VBUS Sensitivity H PLAY/STOP (ENTER) HOLD STOP HOLD STOP...
  • Page 8 ICD-P520/P530F • Switches and corresponding LCD indications Switch Indication DIVIDE (P520) FM•i/5 (P530F) DISPLAY/MENU zXREC/PAUSE NxPLAY/STOP(ENTER) Press DIVIDE button. – . xSTOP > + ERASE (P520) DIVIDE (P530F) Indication after DIVIDE button is pressed. HOLD-OFF HOLD-ON P520 ERASE Indication after DISPLAY/MENU button is pressed.

  • Page 9: Diagrams

    ICD-P520/P530F SECTION 4 DIAGRAMS 4-1. BLOCK DIAGRAM MIC101 P520 MICROPHONE A/D,D/A CONVERTER,DSP IC101 P530F SIGNAL SELECT J101 IC2003 SPEAKER AMP MIC AMP IC102 47 MIP HSSPOOT (PLUG IN POWER) Q106 SP101 RV101 –IN SPEAKER – 23 EGPIO11 XDSPIFRW EGPIO12 BIAS...
  • Page 10 ICD-P520/P530F • Waveforms • IC Block Diagrams THIS NOTE IS COMMON FOR PRINTED WIRING – MAIN Board – BOARDS AND SCHEMATIC DIAGRAMS. IC102 MM3111AWLE (MAIN Board (1/2)) (In addition to this, the necessary note is printed in IC101 (XOUT) IC2002 MM3111AWLE (MAIN Board (1/2)) each block.)

  • Page 11: Printed Wiring Board - Main Section

    ICD-P520/P530F 4-2. PRINTED WIRING BOARD – MAIN SECTION – • See page 10 for Semiconductor Location. • : Uses unleaded solder. S709 MAIN BOARD (SIDE A) MIC101 FM• / P530F MICROPHONE DIVIDE P520 D2008 W102 R102 W502 S705 CN701 –...

  • Page 12: Schematic Diagram - Main Board (1/2)

    ICD-P520/P530F 4-3. SCHEMATIC DIAGRAM – MAIN SECTION (1/2) – • Refer to page 10 for Waveforms. • Refer to page 10 for IC Block Diagrams. R137 RV101 C127 P530F R124 R128 Q101 IC2003 R126 C124 R135 IC B/D R2008 C132...

  • Page 13: Schematic Diagram - Main Board (2/2)

    ICD-P520/P530F 4-4. SCHEMATIC DIAGRAM – MAIN SECTION (2/2) – • Refer to page 10 for Waveforms. • Refer to page 17 for IC Pin Descriptions. (Page 12) IC2001 TP2001 C2003 R727 R726 R728 IC701 R711 R712 D702 D701 NAND02GW3B2CN6F R713...

  • Page 14: Printed Wiring Board - Usb/Fm Section (Icd-P530F)

    ICD-P520/P530F 4-5. PRINTED WIRING BOARD – USB/FM SECTION (ICD-P530F) – • : Uses unleaded solder. USB/FM BOARD (SIDE A) USB/FM BOARD (SIDE B) (Page 11) MAIN BOARD R1005 R2028 CN2001 W1001 MAIN BOARD W2001 R1007 C1003 C1014 C1006 (Page 11)

  • Page 15: Printed Wiring Board - Usb Section (Icd-P520)

    ICD-P520/P530F 4-6. PRINTED WIRING BOARD – USB SECTION (ICD-P520) – • : Uses unleaded solder. USB BOARD (SIDE A) USB BOARD (SIDE B) (Page 11) MAIN BOARD CN2001 W1001 CN1002 TP1001 R1019 R1010 1-869-170- (11) 1-869-170- (11) CN1001 (USB) ICD-P520/P530F...

  • Page 16: Schematic Diagram - Usb/Fm Section (Icd-P530F)

    ICD-P520/P530F 4-7. SCHEMATIC DIAGRAM – USB/FM SECTION (ICD-P530F) – 4-8. SCHEMATIC DIAGRAM – USB SECTION (ICD-P520) – CN1002 R1005 W1001 R1009 IC1001 (Page 12) C1005 C1006 C1014 C1014 C1003 R1007 (Page 12) R1002 R1020 R1010 CN1001 Q1003 R1021 R1024 C1008...
  • Page 17 ICD-P520/P530F • IC Pin Descriptions IC703 MN101C93KSH (SYSTEM CONTROL, USB/LED/LCD DRIVER) (MAIN BOARD (2/2)) Pin No. Pin Name Pin Description 1 to 4 COM0 to 3 LCD common 0 to 3 signal output 5 to 7 VLC3 to 1 LCD VLC 3 to 1 signal input C2/N.C...
  • Page 18 ICD-P520/P530F Pin No. Pin Name Pin Description FLMRB Flash memory ready/busy signal input XFLMWP Flash memory write protect signal output XFLMCS0 Flash memory chip select signal output FLMCLE Flash memory command latch enable signal output FLMALE Flash memory address latch enable signal output...

  • Page 19: Exploded Views

    ICD-P520/P530F SECTION 5 EXPLODED VIEWS Note: • -XX and -X mean standardized parts, so • The mechanical parts with no reference they may have some difference from the number in the exploded views are not sup- original one. plied. • Items marked “*” are not stocked since •...

  • Page 20: Case (Rear) Section

    ICD-P520/P530F 5-2. CASE (REAR) SECTION CN701 LCD701 MIC101 not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-633-874-01 BUTTON (SIDE) (P520) 2-590-020-01 SHEET, INSULATING 2-633-874-21 BUTTON (SIDE) (P530F) 2-633-878-01 TERMINAL (–), BATTERY 2-633-876-01 TERMINAL (+.–), BATTERY...

  • Page 21: Electrical Parts List

    ICD-P520/P530F SECTION 6 MAIN ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in • RESISTORS When indicating parts by reference num- the parts list may be different from the All resistors are in ohms. ber, please include the board name.
  • Page 22 ICD-P520/P530F MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark FB702 1-469-581-21 INDUCTOR, FERRITE BEAD (1005) R128 1-218-949-11 RES-CHIP 1/16W FB2001 1-400-693-21 INDUCTOR, FERRITE BEAD (1005) R129 1-218-977-11 RES-CHIP 100K 1/16W R130 1-218-933-11 RES-CHIP 1/16W < IC >...
  • Page 23 ICD-P520/P530F MAIN USB/FM Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R755 1-218-965-11 RES-CHIP 1/16W < RESISTOR > (P530F) R756 1-218-990-81 SHORT CHIP 0 (P530F) R1003 1-218-937-11 RES-CHIP 1/16W R757 1-218-990-81 SHORT CHIP 0 (P520) (P520)
  • Page 24 ICD-P520/P530F Ver. 1.1 USB/FM Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1002 1-218-965-11 RES-CHIP 1/16W ACCESSORIES (P530F) ************ R1003 1-218-937-11 RES-CHIP 1/16W (P530F) 1-829-882-12 CORD, CONNECTION (USB) R1004 1-218-937-11 RES-CHIP 1/16W 2-059-703-02 POUCH, CARRYING (E,CH,KR)
  • Page 25 ICD-P520/P530F MEMO...
  • Page 26 ICD-P520/P530F REVISION HISTORY Checking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2007.03 2007.06...

This manual is also suitable for:

Icd-p530f

Table of Contents