PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. SX-SW77...
Frequency range ....25 Hz to 1.0 kHz Maximum Input Power ......60 W SX-SW77...
Page 5
Maximum Input Power ......60 W Laboratories."Dolby", "Pro Logic" and the double-D symbol are trademarks of Dolby Laboratories. "DTS" and "DTS Digital Surround" are registered trademarks of Digital Theater Systems, Inc. Receiver subwoofer (SX-SW77) FM antenna (ADH7030) AM loop antenna RECORDER...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SX-SW77 only WVXCN, KUXCN...
Page 7
Packing Sheet AHG7125 Operating Instructions See Contrast table (2) Packing Sheet L AHG7128 (German) (2) CONTRAST TABLE SX-SW77/WYXCN, WVXCN, SX-SW55/WYXCN, WVXCN and SX-SW950/KUXCN are constructed the same except for the following: SX-SW77/ SX-SW55/ SX-SW55/ SX-SW950/ SX-SW77/ Mark No. Symbol and Description...
Page 9
Cushion TX AEB7371 Screw PBZ30P080FTC Rivet AEC7514 Screw PSZ30P060FNI Packing AEC7548 (2) CONTRAST TABLE SX-SW77/WYXCN, WVXCN, SX-SW55/WYXCN, WVXCN and SX-SW950/KUXCN are constructed the same except for the following: SX-SW77/ SX-SW55/ SX-SW55/ SX-SW950/ SX-SW77/ Mark No. Symbol and Description WYXCN WVXCN...
Page 11
Pioneer Name Plate VAM1152 Screw BPZ30P080FNI Screw PSZ30P060FNI DISPLAY Unit See Contrast table (2) (2) CONTRAST TABLE SX-SW77/WYXCN, WVXCN, SX-SW55/WYXCN, WVXCN and SX-SW950/KUXCN are constructed the same except for the following: SX-SW77/ SX-SW55/ SX-SW55/ SX-SW950/ SX-SW77/ Mark No. Symbol and Description...
BU1924FS CN3201 B2P-VH B2P-VH ADX7485 B2P3S-VH ANALOG INPUT (SX-SW950 AUX) ADX7487 11pin FFC ADD7506 B2P3S-VH AC INLET ASSY WYXCN,WVXCN:AWU8273 TUNER MODULE KUXCN:AWU8274 WYXCN, WVXCN:AXX7170 KUXCN:AXX7172 WYXCN,WVXCN:XKP3084 KUXCN:XKP3085 AC CORD ANALOG AUDIO SIGNAL DIGITAL or PWM AUDIO SIGNAL COMMUNICATION LINE SX-SW77...
Page 15
FAN VOLTAGE TABLE R5608 ROTATION POWER VOLTAGE GNDF GNDD -19.10 VSF+12 12.3 Not Digital Stream. -25.30 VSFAN (The Analog IN is excluded) VFDP VSF+12 13.1 Analog IN (VOL19 or less) VSFAN VSF+12 13.0 HIGH 12.2 VOL20 or more VSFAN SX-SW77...
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B Chip Part P.C.Board transistor Resistor array 3-terminal regulator SX-SW77...
W112 GNDD GNDD W113 GNDD GNDD C5652 W114 GNDD GNDD D5652 D5653 D5654 D5655 W115 GNDD D5657 GNDD C5653 D5651 FLDC+ W123 FLDC+ C5651 (ANP7546-C) (ANP7546-C) SIDE A SIDE B AC INLET ASSY (ANP7546-C) (ANP7546-C) SIDE A SIDE B SX-SW77...
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k Ω 562 x 10 5621 RN1/4PC 5 6 2 1 7 7 7 7 LIST OF HOLE PCB ASSEMBLIES SX-SW77/ SX-SW77/ SX-SW55/ SX-SW55/ SX-SW950/ Mark Symbol and Description...
Page 39
7 7 7 7 PCB PARTS LIST FOR SX-SW77/WYXCN UNLESS OTHER WISE NOTED Mark No. Description Part No. Mark No. Description Part No. C814,C816,C821,C828,C832 CCSRCH471J50 MAIN ASSY C951 CCSRCH471J50 SEMICONDUCTORS C5716 CCSRCH561J50 C819,C820 CCSRCH6R0D50 IC601 AK4117VF C3108,C3111,C3117,C3120 CEAL100M16 IC3191 BA10358F...
CN5 2P VH CONNECTOR B2P3S-VH > AN1 1P AC INLET XKP3084 6. ADJUSTMENT CONNECT ASSY SEMICONDUCTORS There is no information to be shown in this chapter. D5651-D5655,D5657 UDZS8R2(B) CAPACITORS C5651-C5654 CKSRYB102K50 OTHERS CN5652 12P CONNECTOR AKP7131 CN5651 13P PLUG XKP3066 SX-SW77...
[FL display] DVD/DVR1 S E R S E R DVD/DVR2 S E R S E R DIGITAL S E R PC/GAME S E R ANALOG S E R S E R FM/AM S E R TUNER S E R SX-SW77...
Page 42
However, it is not counted during Standby mode. • The maximum countable power-on time is 255H59M (255 hours 59 minutes.) The indication will not advance beyond that. • The accumulated power-on time basically cannot be cleared. Test Mode connecting point MAIN ASSY SIDE B Connecting point SX-SW77...
Note: Be sure to select the setting corresponding to the model number of the speaker. (See the table below.) Destination Model Number Speaker Remarks Speaker setting Europe SX-SW55/WYXCN, /WVXCN SMALL1 REGULAR1 SX-SW77/WYXCN, /WVXCN TALL TALL North America SX-SW950/KUXCN Japan SX-06SW/JJXCN AV GATE AV rack with SP AV GATE SX-E230SW/JJXCN...
Press the "SOUND" key in test mode, to select the mode that DSP error messages are displayed. Press the "SOUND" key again to select the normal test mode. For this reason, make the usual function of "SOUND" not effective in the test mode. SX-SW77...
UNBAL75Ω LOOP ANTENNA AUDIO INPUT DIGITAL SYSTEM CONTROL SPEAKERS DVD/DVR 1 DVD/DVR 2 DIGITAL ANALOG CONNECTOR SURROUND OUTSUB WOOFER (COAXIAL) (OPTICAL) (OPTICAL) USE ONLY WITH DISPLAY UNIT CENTER FRONT Negative Speaker Terminal Do not short-circuit Ground (Chassis) SX-SW77...
Conditions: The above prerequisite is upheld, and the conditions for an overcurrent detection are met. 5. Process when the protection circuits are activated The unit is shut down within 30 ms after abnormality detection then the volume level is set to 0. The unit can be turned on immediately after the shutdown. SX-SW77...
Low speed, with audio input, VSF+12 13.1 with VOL 19 or less VSFAN High speed, with VOL 20 or more VSF+12 13.0 VSFAN 12.2 7-V drive circuit Note: The above voltage values are references. They differ from product to product. SX-SW77...
Display cover single motion. Thin slot screwdriver Rear view Remove the three screws. Unhook the two hooks. Remove the FL and CONNECT Assys. Bottom view Rear view Remove the cosmetic baffle. FL Assy CONNECT Assy Cosmetic baffle SX-SW77...
Page 49
Remove the four screws. Remove the four screws. Remove the speaker. Speaker Bottom view Rear view Disconnect the connection cord. Remove the two screws. Pull out the Main Section. Main Section Disconnect the connection cord. Connection cord Rear view Speaker SX-SW77...
Page 50
POWER SUPPLY Unit Note : Coil the ferrite clamp with the lead wire AC INLET Assy three turn in exchange of Ferrite Clamp (DTH1158) or 4P Lead with Housing (ADX7487). EMC is not good when does not coil it. Diagnosis SX-SW77...
Page 51
Interrupt 1 Pin INT0 Interrupt 0 Pin Power-Down & Reset Pin When "L", the AK4117 is powered-down and reset, and all output pins go to "L" and the control registers are reset to default state. − AVSS Analog Ground Pin SX-SW77...
Page 52
Port F3 Port F4 Port F5 − IO_VDD I/O power supply (3.3V) Port F1 Port F0 − IO_GND GPIO I/O Ground Port F9 SCAN SCAN-Manufacturing test pin. This pin should be pulled low. PF10 Port F10 − IO_GND I/O ground SX-SW77...
Page 53
I/O power supply (3.3V) 76 SCKR/PC0 Receiver Serial Clock/Port C0 77 SCKT/PC3 Transmitter Serial Clock/Port C3 78 FSR/PC1 Frame Sync for Receiver/Port C1 79 FST/PC4 Frame Sync for Transmitter/Port C4 80 SDO5/SDI0/PC6 Serial Data Output 5/Serial Data Input 0/Port C6 SX-SW77...
Page 55
Emph late PWM_L Line Out MUTE .14 Soft Soft Loud Intarpo 58,57. PWM_P&M6 R Surround Comp DRC SRC NS PWM Blquads Tone Block Emph late HP_SEL .12 PWM_R Line Out BKND_ERR .37 39. VALID Volume Control PSVC 32. PSVC SX-SW77...
Page 56
PWM_M_4 PWM 4 output (differential –) PWM_P_4 PWM 4 output (differential +) VR_PWM Voltage reference for digital PWM core supply 1.8V PWM_M_7 PWM 7 (Line out L) output (differential –) PWM_P_7 PWM 7 (Line out L) output (differential +) SX-SW77...
Page 57
PWM right channel headphone (differential +) MCLK MCLK is a 3.3V clock master clock input − RESERVED Connect to digital ground Note of types : A = analog, D = 3.3V digital, P = power/ground/decoupling, I = input, O = output SX-SW77...
Page 59
54 BST_A pin, capacitor connected to REG_GND capacitor to OUT_A required Voltage supply to on-chip gate drive and − 27 GND Power ground 55 GVDD digital supply voltage regulators − − 56 GND 28 GND Power ground Power ground SX-SW77...
Page 60
Control of DSPMUTE combining DIRERR., "H" at digital mode, "L" at analog mode. ADMD XDSPMUTE MUTE requeat to DSP MODULE (LED) Control for subwoofer mix XDEC MUTE Detection of 1stDSP boot success from DSP MODULE DSPHREQ Error detection from DSP(MOTOROLA) − VSS4 VSS4 Ground − VDD4 VDD4 Power supply SX-SW77...
Page 61
D-AMP MUTE (PSVC) Power Supply Voltage Control DIGSEL DIGITAL INPUT SELECT INPUTSELA AUDIO INPUT SELECT XADPDN POWER DOWN for A/D SHUTDWN D-AMP SHUTDOWN detection (DCDET) D-AMP DC detection XOTW D-AMP Over Temperature Warning PB7/D7 (FREQCONT1) Frequency control1 for SMPS SX-SW77...
Page 62
• PortE and PortF can be selected for input or output by each 2 bits. • In case of without RDS, it is best that RDSDATA and RDSCLK are assigned as I/O port which can be set output and output low level. SX-SW77...
Page 63
Pin Name Pin Function Chip select input Serial clock input Start bit, OP code, address and serial data inputs Serial data output and READY/BUSY internal state display output − Ground − Non connection − Non connection − Power supply SX-SW77...
– Lights when in one of the RDS display or search modes. Rear Panel (Receiver subwoofer) ANTENNA UNBAL75Ω LOOP ANTENNA AUDIO INPUT DIGITAL SYSTEM CONTROL SPEAKERS DVD/DVR 1 DVD/DVR 2 DIGITAL ANALOG CONNECTOR SURROUND OUTSUB WOOFER (COAXIAL) (OPTICAL) (OPTICAL) USE ONLY WITH DISPLAY UNIT CENTER FRONT AC IN SX-SW77...
Remote control (SX-SW77) Function select buttons RECORDER RECEIVER Press to select the hard disk (HDD) for recording or MUTE playback. The receiver subwoofer's audio input is VOLUME – also switched to DVD/DVR2. FM/AM AUDIO INPUT Press to select the DVD for recording or playback.
Page 69
TV's tuner, and 'DVD When GUIDE Plus+ is displayed, use to display the mode', in which you get picture and sound from the previous/next day. systemís tuner (or an external input). SX-SW77...
Page 70
Press to switch the receiver on or into standby. + SHIFT: TEST TONE 4 VOLUME +/– Use to output the test tone (for speaker setup) Use to adjust the volume. 14 RETURN Press to go back one level in the on-screen menu or display. SX-SW77...
Page 71
Press to change the zoom level. DISPLAY Press to display/change the current disc information. 18 TV CONTROL After setting up, use these controls to control your TV. 19 SHIFT Press to access functions on the remote printed in green. SX-SW77...
Page 72
For checking audio at the SP terminal SDS1175 (FR/RED), SDS1176 (SL/BLUE) SDS1177 (SR/GRAY), SDS1178 (C/GREEN) CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Fans Cleaning paper : GED-008 SX-SW77...